Jin‐Seong Park

The effect of water exposure on amorphous indium-gallium-zinc oxide (a-IGZO) semiconductors was reported. It was found that water can diffuse in and out of the a-IGZO film, reversibly affecting the transistor properties. Two competing mechanisms depending on the thickness of the active channel were clarified. The electron donation effect caused by water adsorption dominated for the thicker a-IGZO films (⩾100nm), which was manifested in the large negative shift (>14V) of the threshold volt

We have fabricated 6.5 in. flexible full-color top-emission active matrix organic light-emitting diode display on a polyimide (PI) substrate driven amorphous indium gallium zinc oxide thin-film transistors (a-IGZO TFTs). The a-IGZO TFTs exhibited field-effect mobility (μFE) of 15.1 cm2/V s, subthreshold slope of 0.25 V/dec, threshold voltage (VTH) of 0.9 V. The electrical characteristics of TFTs on PI substrate, including a bias-stress instability after 1 h long gate bias at 15 V, were indisting

Flexible organic light emitting diode (OLED) will be the ultimate display technology to customers and industries in the near future but the challenges are still being unveiled one by one. Thin-film encapsulation (TFE) technology is the most demanding requirement to prevent water and oxygen permeation into flexible OLED devices. As a polymer substrate does not offer the same barrier performance as glass, the TFE should be developed on both the bottom and top side of the device layers for sufficie

The effect of Ar plasma treatment on amorphous indium gallium zinc oxide (a-IGZO) thin films was investigated. The net electron carrier concentration (1020–1021cm−3) of the a-IGZO thin films dramatically increased upon their exposure to the Ar plasma compared to that (1014cm−3) of the as-deposited thin film. The authors attempted to reduce the contact resistance between the Pt∕Ti (source/drain electrode) and a-IGZO (channel) by using the Ar plasma treatment. Without the treatment, the a-IGZO thi

We investigated the feasibility of controlling the threshold voltage (Vth) by adjusting the thickness of the active layer (tactive) rather than by conventional chemical doping in indium-gallium-zinc oxide (IGZO) transistors with an inverted staggered structure. The value of Vth of the IGZO transistor was linearly modulated from −15.3±1.6to−0.1±0.21V by reducing tactive without any significant change in the field-effect mobility (μFE), subthreshold gate swing, or Ion∕off ratio. The free electron

This paper describes the recent advances in flexible oxide thin-film transistors (TFTs), one of the rapidly emerging technologies for the next-generation display applications. First, the paper focuses on the effect of the buffer layer over the plastic substrate, which significantly influences the electrical performance and stability of oxide TFTs. Then oxide semiconductor TFTs fabricated through atomic layer deposition among the various oxide semiconductor fabrication methods were reviewed due t

The flat panel display (FPD) market has been experiencing a rapid transition from liquid crystal (LC) to organic light emitting diode (OLED) displays, leading, in turn, to the accelerated commercialization of OLED televisions already in 2013. The major driving force for this rapid change was the adaptation of novel oxide semiconductor materials as the active channel layer in thin film transistors (TFTs). Since the report of amorphous-InGaZnO (a-IGZO) semiconductor materials in 2004, the FPD indu

The plasma-enhanced atomic layer deposition (PEALD) of tantalum nitrides (TaN) thin films has been performed using terbutylimidotris(diethylamido)tantalum and hydrogen radicals at a temperature of 260 degreesC. The film thickness per cycle is also self-limited at 0.8 Angstrom /cycle, which is thinner than that of the conventional atomic layer deposition (ALD), 1.1 Angstrom /cycle. X-ray diffraction analysis indicates that the as-deposited films are not amorphous but polycrystalline mixed with cu

This review article introduces the recent advances in the development of oxide semiconductor materials based on solution processes and their potential applications. In the early stage, thin film transistors based on oxide semiconductors fabricated by solution processes used to face critical problems such as high annealing temperatures (>400 °C) required to obtain reasonable film quality, and the relatively low field effect mobility (<5 cm2 V−1 s−1) compared to devices fabricated by conventional

Abstract Since the first report of amorphous In–Ga–Zn–O based thin film transistors, interest in oxide semiconductors has grown. They offer high mobility, low off-current, low process temperature, and wide flexibility for compositions and processes. Unfortunately, depositing oxide semiconductors using conventional processes like physical vapor deposition leads to problematic issues, especially for high-resolution displays and highly integrated memory devices. Conventional approaches have limited

We investigated the effect of the high-k TiOx (k∼40) gate dielectric on the mobility (μFE) of indium-gallium-zinc oxide (IGZO) transistors. As the thickness of the TiOx layer at the interface of the IGZO channel and SiNx gate dielectric layer increased from 2 to 8 nm, the μFE value was monotonously reduced from 9.9 to 1.8 cm2/V s. The degradation of the mobility was attributed to the Coulomb scattering mechanism rather than the phonon scattering mechanism of the high-k TiOx layer based on the be

Plasma-enhanced atomic layer deposition (PEALD) of tantalum nitride (Ta-N) thin films at a deposition temperature of 260°C using hydrogen radicals as a reducing agent for tertbutylimidotris(diethylamido)tantalum is described. The PEALD yielded superior Ta-N films with an electric resistivity of 400 μΩ cm and no aging effect under exposure to air. The film density was higher than that of Ta-N films formed by typical ALD, in which is used instead of hydrogen radicals. In addition, the as-deposited